Solar Desalination salt and mineral recovery system.

Equipment required:

10,000 gpd vapor compressor

1000 gallon recycle tank
500 gallon brine tank

Useful information

1 cubic foot water = 7.48 gallons

1 gallon water = 8.34 pounds

1 cubic foot of water weighs approximately 62pounds

1 cubic foot of concentrated solids to 5% moisture weighs approximately 100 pounds

Sand w/ Gravel, wet = 125 pounds per cubic foot

Sand w/ Gravel, dry = 108 pounds per cubic foot


 

10,000 gpd at 1000ppm = 8,340 pounds solids per 1,000,000,000 gallons (83.4 pounds of solids per 10,000 gallons).


A 10,000 gpd vapor compressor generates 9,000 gallons of distilled water and 1,000 gallons of reject brine water at 10,000 ppm if the influent is 1,000 ppm.

 

This 1,000 gallons of 10,000 ppm reject water must be compressed , yielding 900 gallons of distilled water and 100 gallons of reject brine at 100,000 ppm (84 pounds).

 

900 gallons of 10,000 ppm reject brine should be added to the 100 gallons of 100,000 ppm reject brine water in the 1,000 gallon tank, producing 1000 gallons of reject brine water at 15,000 ppm (approximately 150 pounds solids).

 

The 1000 gallons of reject brine water at 15,000 ppm will be compressed to 100 gallons of 150,000 ppm reject brine.

 

900 gallons of 10,000 ppm reject brine should again be added to the 100 gallons of 150,000 ppm reject brine (approximately 225 pounds solids) This batch should be compressed and stored in the 500 gallon brine tank for solids recovery.

 

The final reject brine is at 210 degrees Fahrenheit and will cause rapid evaporation. Supersaturation may be achieved with no additional heat.

 

 

SunDragon Desalination Salt Factory's No Salt Brine Solar and conventional heat salt and mineral recovery system. zero discharge waste brine   Avoid permitting problems, discharge restrictions, fines and surcharges! The salt problem in saline waters by drying and solidifying the impurities from the feed or discharge water. Solar Desalination salt and mineral recovery system. Avoid permitting problems, discharge restrictions, fines and surcharges zero discharge waste brine SunDragon Desalination Systems SunDragon Salt Factory Systems exsiccation technology turns saline feed water into 100% distilled water and 100% dried salt. Salt and impurities recovery in a dried solid form. Particles, scaling and biofouling, Calcium carbonate scaling, Biofilm removal and control are what a SunDragon is designed to do. SunDragon have 2 water streams(influent high TDS, effluent lower TDS) a zero brine discharge solution for the desalination and wastewater industries. The salt doesn't go away. SunDragon collects all the salt and impurities from seawater or brackish ground water, producing dried salt and impurities with a distilled water effluent. Pounds of Salts and Solids per 1 Million U S Gallons of Water Desalinated Based on ppm/tds Brackish: 1,000ppm = 8,335.8822 Pounds of Salt Brackish: 5,000ppm= 41,679.411 Pounds of Salt Highly Brackish:15,000ppm = 125,038.234 Pounds of Salt Saline: 30,000 ppm = 250,076.468 Pounds of Salt Sea Water: 40,000 ppm = 333,435.291 Pounds of Salt Brine: 300,000+ ppm = 2,500,764.681 Pounds of Salt For more information email sundragonsaltfactory@yahoo.com Phone 561 271 8131

No permitting for discharge stream disposal!

 

Why we use Vapor Compression Distillation (VCD) technology:

The most economical source of quality, distilled water, is VCD. VCD can handle the broadest spectrum of constituents however VC requires energy. The land and capital cost savings by use of VC distillation is significant when used for water heating with SunDragon technology.

 

NASA Marshall Space Flight Center Environmental Control and Life Support Systems, or simply, ECLSS.which utilizes the Vapor Compression Distillation (VCD) technology.Image

 

SunDragon works best with vapor compressions hyper-saline brine discharge at 212 Degrees F

 

Pounds of Salts and Solids per 1 Million U S Gallons of Water Desalinated

Based on ppm/tds


Brackish: 1,000ppm = 8,335.8822 Pounds of Salt

Brackish: 5,000ppm= 41,679.411 Pounds of Salt
Highly Brackish:15,000ppm = 125,038.234 Pounds of Salt
Saline: 30,000 ppm = 250,076.468 Pounds of Salt
Sea Water: 40,000 ppm = 333,435.291 Pounds of Salt
Brine: 300,000+ ppm = 2,500,764.681 Pounds of Salt